Ford Mustang Service Manual: Automatic Transmission
- Automatic Transaxle/Transmission
- Transmission Description (Description and Operation)
- Identification Tags
- Range Selection
- Shift Patterns
- Torque Converter (Description and Operation)
- Geartrain
- Apply Components
- Hydraulic System
- Transmission Electronic Control System
- Diagnostic Strategy
- Preliminary Inspection
- Shift Point Road Test
- Torque Converter Diagnosis
- Diagnostics
- Output State Control (OSC) Mode
- Transmission Drive Cycle Test
- Diagnostic Trouble Code Charts
- Transmission Connector Layouts
- Pinpoint Tests - OSC Equipped Vehicles
- Special Testing Procedures
- Leakage Inspection
- Transmission Fluid Cooler
- Diagnosis By Symptom
- Transmission Fluid Cooler - Backflushing and Cleaning
- Transmission Fluid Drain and Refill
- Fluid Pan, Gasket and Filter
- Transmission Filler Tube
- Main Control Valve Body
- Extension Housing Seal and Gasket
- Electronic Pressure Control (EPC) Solenoid
- Manual Control Lever Shaft and Seal
- Digital Transmission Range (TR) Sensor
- Reverse Servo Assembly
- Overdrive Servo
- 1-2 Accumulator
- 2-3 Accumulator
- Transmission Support Crossmember
- Transmission (REMOVAL)
- Transmission (DISASSEMBLY)
- Main Control Valve Body
- Pump and Intermediate Clutch Piston
- Intermediate One-Way Clutch
- Reverse Clutch
- Forward Clutch Cylinder
- Planetary Gear Support Assembly and Planetary One-Way Clutch
- Reverse Sun Gear
- Output Shaft and Direct Clutch Cylinder
- Torque Converter (Disassembly and Assembly of Subassemblies)
- Torque Converter Cleaning And Inspection
- Torque Converter Leak Check
- Torque Converter Impeller to Pump Stator Interference Check
- Torque Converter End Play Check
- Torque Converter Turbine to Pump Stator Interference Check
- Transmission (ASSEMBLY)
- Transmission (INSTALLATION)
- Transaxle/Transmission Cooling
- Automatic Transaxle/Transmission External Controls
Installation
Removal
1. Disconnect the electrical connectors from the EGR vacuum regulator
solenoid, the
supercharger bypass vacuum solenoid, and the differential pressure
feedback EGR system.
2. Disco ...
Automatic Transaxle/Transmission
General Specifications
a - MERCON V is not interchangeable at this time with the current MERCON
fluids. Check the
transmission fluid level indicator to determine the correct fluid and refer to
the ...
Other materials:
Transmission (Disassembly)
Manual Transmission
The TR3650 five-speed manual transmission features the following:
The fifth speed gear functions as an overdrive gear.
The forward gears are synchronized and helical cut.
The reverse gear operates through a constant-mesh, fully
...
Halfshaft Joint
Rear Drive Halfshafts (Description and Operation)
The rear wheel drive halfshaft system consists of and operates as
follows:
Halfshafts (4K138) transmit engine torque from the rear axle housing to
the rear wheels.
Halfshafts rotate at approximately one ...
Hydraulic Brake Actuation (Description and Operation)
Hydraulic Brake Actuation (Description and Operation)
CAUTION: Blistering or swelling of rubber brake components may indicate
contamination
of the brake fluid by a petroleum based substance. New rubber components must be
installed
in the hydraulic ...